MATERIAL SAFETY DATA SHEET
1 CHEMICAL PRODUCT & COMPANY IDENTIFICATION
Trade Name DETERGENT DISINFECTANT PUMP SPRAY
Manufacturer APDC, Inc.
5047 Martin Luther King Frwy
Fort Worth, TX 76119
Telephone Numbers - 24 Hour Emergency Assistance Telephone Numbers - General Assistance
Medical - 800-228-5635 General -(817) 395-0120
Chemtrec - 800-424-9300
Chemtrec Int'l - 703-527-3887
2 HAZARDS IDENTIFICATION
Emergency Overview
Clear liquid,
May cause irritation to eyes and skin.
Health Effects: Eyes
This product may cause irritation to the eyes.
Health Effects: Skin
This product may cause irritation to the skin.
Health Effects: Inhalation
Exposure via inhalation not likely. High vapor or aerosol mist concentrations may be irritating to the nose,
throat and upper respiratory tract.
Health Effects: Ingestion
Ingestion may cause transient irritation of throat, stomach and gastrointestinal tract. Ingestion of large
amounts may produce gastrointestinal disturbances including irritation, nausea, and diarrhea.
3 COMPOSITION / INFORMATION ON INGREDIENTS
Ingredient Name CAS Number Percent
_Diethylene glycol monobutyl ether 112-34-5 8 %
_Alkyl dimethyl benzyl ammonium chloride (C12-18) 68391-01-5 0.105 %
_Alkyl (68% C12, 32% C14) dimethyl ethylbenzyl ammonium chloride 85409-23-0 0.105 %
(Alt CAS 68956-79-6)
4 FIRST AID MEASURES
Eyes
Immediately flush eyes with water for at least 15 minutes while holding eyelids open. If irritation persists get
medical attention.
Skin
Immediately take off all contaminated clothing.Wash contaminated clothing before reuse.For skin contact,
flush with large amounts of water. If irritation persists, get medical attention.
Inhalation
If symptoms are experienced, remove source of contamination or move victim to fresh air.If symptoms
persist, get medical attention. If not breathing, give artificial respiration, preferably mouth-to-mouth. If
breathing is difficult, give oxygen. Seek medical attention.
Ingestion
Do not induce vomiting.If ingestion of a large amount does occur, seek medical attention.Never give
anything by mouth to a victim who is unconscious or is having convulsions.
Notes to Physician
If the product is ingested, probable mucosal damage may contraindicate the use of gastric lavage. Treat the
affected person appropriately.
5 FIRE FIGHTING MEASURES
Flash Point (> 93.9 °C), > 201 F PMCC
Extinguishing Media
Use appropriate methods for combatting the surrounding fire.
Fire Fighting Equipment / Instructions
Firefighters should wear full fire-fighting turn-out gear (full Bunker gear) including NIOSH-approved
self-contained breathing apparatus with full facepiece operated in the pressure demand or other positive
pressure mode.
6 ACCIDENTAL RELEASE MEASURES
SPILL AND LEAK PROCEDURES
Emergency Action:
Isolate spill or leak area immediately. Keep unauthorized personnel away.Stay upwind.Keep out of low
areas.Ventilate closed spaces before entering.
Do not touch or walk through spilled material. Wear appropriate personal protective equipment during
cleanup.Small Spills: Absorb with earth, sand or other non-combustible material and transfer to containers
for later disposal. Large Spills: Dike ahead of liquid spill for later disposal.
Do not discharge effluent containing this product into lakes, streams, ponds, estuaries, oceans or other
waters unless in accordance with the requirements of a National Pollutant Discharge Elimination System
(NPDES) permit and the permitting authority has been notified in writing prior to discharge. Do not
discharge effluent containing this product to sewer systems without previously notifying the local sewage
treatment plant authority. For guidance, contact your State Water Board or Regional Office of the EPA.
7 HANDLING & STORAGE
Handling Procedures
Avoid contact with skin and eyes.Avoid breathing vapors or mists of this product.Wash thoroughly after
handling.As with all chemicals, good industrial hygiene practices should be followed when handling this
material.
Storage Procedures
Store in a dry, well-ventilated area.Avoid freezing or excessive heat.
DO NOT CONTAMINATE WATER, FOOD OR FEED BY STORAGE OR DISPOSAL.
Engineering Controls
Use with adequate ventilation.
8 EXPOSURE CONTROLS / PERSONAL PROTECTION
Personal Protective Equipment: Eyes/Face
Wear safety glasses with side shields.
Personal Protective Equipment: Skin
Use impervious gloves.Wear suitable protective clothing.
Personal Protective Equipment: Respiratory
Under normal conditions, respirator is not normally required.If vapors are present or irritation is experienced,
NIOSH approved respiratory protection for ammoniacal vapors should be worn.
Personal Protective Equipment: General
Eye wash fountain and emergency showers are recommended.
_Diethylene glycol monobutyl ether 112-34-5
NIOSH - Health Standards - Exposure Limits reduce exposure to lowest feasible concentration
9 PHYSICAL & CHEMICAL PROPERTIES
Flash Point (> 93.9 °C), > 201 F PMCC
Boiling Point (> 100 °C), > 212 F
Specific Gravity (1.007 g/ml), 8.38 lb/gal
Solubility in Water Complete
pH Value 11.7
Freezing Point (> 0 °C), > 32 F
Appearance and Odor
Clear liquid,
Chemical Stability
Stable under normal conditions
Conditions to Avoid
Avoid strong oxidizing agents.
Incompatibility
Strong acids, alkalies and oxidizing agents.
Hazardous Decomposition
Upon decomposition, this product may yield oxides of nitrogen and ammonia.
Hazardous Polymerization
Will not occur.
10 TOXICOLOGICAL INFORMATION
Carcinogenicity
Not listed as carcinogenic according to IARC, NTP or OSHA.
_Tetra sodium ethylenediamine tetra acetic acid (Na4 EDTA) 64-02-8
Toxicology Data - Selected LD50s and LC50s Oral LD50 Rat: 1658 mg/kg
_Water 7732-18-5
Toxicology Data - Selected LD50s and LC50s Oral LD50 Rat: >90 mL/kg
_Diethylene glycol monobutyl ether 112-34-5
Toxicology Data - Selected LD50s and LC50s Oral LD50 Rat: 3384 mg/kg; Dermal LD50 Rabbit: 2700 mg/kg
11 ECOLOGICAL INFORMATION
Ecotoxicity
Toxic to fish.Toxic to aquatic organisms.
12 DISPOSAL CONSIDERATIONS
Disposal Instructions
CONTAINER DISPOSAL: Plastic Containers: Triple rinse (or equivalent). Then offer for recycling or
reconditioning, or puncture and dispose of in a sanitary landfill, or incineration, or, if allowed by state and
local authorities, by burning. If burned, stay out of smoke. For containers 1 gallon or less: Do not reuse
empty container (bottle, can, bucket). Wrap container and put in trash.
PESTICIDE DISPOSAL - Pesticide wastes are acutely hazardous. Improper disposal of excess pesticide,
spray mixture, or rinsate is a violation of Federal Law. If these wastes cannot be disposed of by use
according to label instructions contact your State Pesticide or Environmental Control Agency, or the
Hazardous Waste representative at the nearest EPA Regional Office for guidance.
13 TRANSPORT INFORMATION
DOT Proper Shipping Name Refer to bill of lading or container label for DOT or other
transportation hazard classification, if any.
14 REGULATORY INFORMATION
_Diethylene glycol monobutyl
ether
112-34-5
CAA (Clean Air Act) - 1990 Hazardous Air [present] (includes mono- and di- ethers of Ethylene glycol,
Pollutants and Triethylene glycol as specified by referenced formula)
CERCLA/SARA - Section 313 - Emission concentration; Chemical Category N230; (applies to
R-(OCH2CH2)n-OR'''' ethers, where n = 1,2, or 3''''; R=alkyl
C7 or less or R = phenyl or alkyl subst. phenyl; R'''' = H or
alkyl C7 or less, or OR'''' consisting of carboxylic acid ester,
sulfate, phosphate, nitrate, or sulfonate)
EPA - Designated Generic Categories - Certain RR-00067-9
Glycol Ethers
TSCA (Toxic Substances Control Act) - Section 4 40 CFR 799.1560
- Chemical Test Rules (40 CFR 79)
U.S. Federal Regulations
Ingredient Name CAS Number Percent
_Diethylene glycol monobutyl ether 112-34-5 8 %
_Alkyl dimethyl benzyl ammonium chloride (C12-18) 68391-01-5 0.105 %
_Alkyl (68% C12, 32% C14) dimethyl ethylbenzyl ammonium chloride 85409-23-0 0.105 %
(Alt CAS 68956-79-6)
State Regulations
This product may contain the following ingredient(s) known to the State of California to cause cancer, birth
defects or other reproductive harm:Ethylene Oxide (CAS RN: 75-21-8)Nitrilotriacetic acid (NTA) (CAS RN:
139-13-9)
Inventories
This product is considered a pesticide, and is therefore excluded from the United States TSCA Regulations.
There is no calculable reportable quantity (RQ) for this product.
Disclaimer
Disclaimer: Nothing contained herein grants or extends a license, express or implied, in connection with
patents, issued or pending, of the manufacturer or others. The information contained herein is based on the
manufacturer's own study and the works of others. The manufacturer makes no warranties, expressed or
implied, as to the accuracy, completeness, or adequacy of the information contained herein. The
manufacturer shall not be held liable (regardless of fault) to the vendee's employees, or anyone for any direct,
special or consequential damages arising out of or in connection with the accuracy, completeness, adequacy
or furnishing of such information.
15 OTHER INFORMATION
HAZARD RATINGS HMIS NFPA
Health 1 1
Flammability 1 1
Reactivity 0 0
PPE X
|